1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162 
CM man gets back to the land
Page 20
Page 21
If you've noticed an error in this article please click here to report it so we can fix it.
JJ Bardon spent five gruelling vveeKs hauling potatoes with
agricultural tractor and trailer combinations in Herefordshire and Shropshire. His report is depressing — and frightening.
HAVING HOOKED UP my Fendt 924 and heavy-duty trailer I set out with 18 other tractor/trailer combinations and their mostly young novice drivers for the harvesting fields in east Herefordshire. There are at least 150 other similar combinations on the roads around us in Hereford and Shropshire.
I'm soon loaded up and pull out onto the road. The unit pulls well enough but chucks heavily and I can feel the very heavy load throughout the 21-mile journey back to base through numerous villages and roundabouts in urban and rural areas. I drive on to the scales in the complex before tipping the load and up on the screen comes 37,400kg I On most days we make three round trips totalling 150 miles, so in seven days we're covering nearly 1,100 miles. I work from 7am to between 9pm and 11pm every day and get a maximum of five hours' sleep, but I just have to keep going.
Most of the drivers are running through roundabouts at almost full speed about 33mph -fully loaded and frequently on their mobile phones as well. This gives a visible whiplash effect to the drawbar and the wheel studs of these very large and heavy trailers, some of which are brand new.
This flat-out running inevitably begins to take its toll with tractors and trailers needing studs tightened. A piston has gone on one tractor and another 06-rag unit needs some attention to its gearbox.
There's a problem with one combination which has an excessive weight of 36,000kg -the hydraulic rams won't lift the body of the trailer to tip the load. They disconnect one of the three rams to give the pump more capacity. This actually works, but it will probably cause long-term damage.
Late one night a tractor/trailer combination in front of me just made it off the A49 into the entrance of the complex when it lost a complete rear-axle unit and a wheel from the tractor.
On leaving a difficult field in the north of the county in week three, running at least 36,000kg, I find I am getting severe brake fade as I come down a gradient at least a mile long with a geriatric driver in front of me who is slowing to a crawl. Fortunately I manage not to hit her.
On my return to the workshop I find the reason: a leaking air valve on the trailer. I notice there is no tread at all on two tyres on one side of the same trailer I picked up two hours earlier. I learn to my horror there is no legal limit on tread depth on agricultural trailer tyres in the UK. As long as there's no wire protruding from the tyre, it seems you can carry on.
Fifteen weeks of tractor/trailer work at 14 hours a day on a potato harvest is more work than the tractors will do in the rest of the year and most of the trailers are not serviced or prepared for this intensive work period.
The vast majority of heavy-duty (240-300hp) tractors have their steering set up for ploughing fields, not for hauling a 25tonne load on blacktop. The power steering is extremely high geared and overreacts on an asphalt surface which feels really dangerous.
In addition, if the variomatic models are over-revved they cut out, losing the power steering and braking and this usually occurs when gearing down on a severe decent. The only way to regain control is to switch the ignition off and on again rapidly and select a high gear.
One Sunday an experienced relief driver stands in for me. On the last journey back to the depot late at night he forgets to engage the electronic lock for the hydraulics and accidentally nudges the tail-gate lever, spreading 10 tonnes of spuds and soil overa mile of theA49. As it was Sunday night there was very little traffic and nobody was injured. This could happen to any driver, but such incidents are inevitable when working so intensively over long periods.
The incidents that are being played out around us become the subject of daily conversations with the drivers I'm working with. One day I get into an argument with the farm manager and the drivers about the use of flashing beacons they claim they are only legally required on dual carriageways. In fact the law states that their use is also required wherever and whenever a hazard is present and I continue to use mine wherever it is called for for which I get much abuse.
These same drivers refuse to use them even when travelling through very narrow lanes with high hedges and have to back up with the loaded trailer lifted, day and night, to let other traffic pass.
One day we come upon Vosa officers in shiny new vehicles who have set up shop in a lay-by on the A49. They stop only commercial vehicles for most of the day despite dozens of agricultural tractor/trailer combinations flying by every hour, all grossly overloaded at this point in the journey.
Finally, in the late afternoon, they stop one of our kind and he gets done for two minor light and drawbar height offences. Amazingly the Vosa officers do not weigh the unit: they simply ask how much weight he is carrying. A figure is quoted. They take that unit off the road there and thenbut only for the drawbar clearance offence, not the overload.
A 10-year-old child could have seen what the main offence was! One of the most hairraising activities in potato harvesting has to be putting a loose trailer cover on 20 tonnes of spuds at the side of the road on heavy rain especially when the load is right up to the edge of the trailer.
All of this is carried out while balancing on the edge of the load, grappling with a wet, slippery cover that can only go on one way round, standing nine foot above the ground. Outrageously, none of these trailers have adequate steps or grab handles this is a great way to obtain a permanent knee injury.
If health and safety want to do something useful in the agricultural industry then they should carry out this procedure a few dozen times and then ban loose covers on agricultural vehicles outright.
My combination, now a 56-reg John Deer 6920S and a 15rn3 trailer, is heading out one morning having just had the fuel filters changed because of sluggish pulling uphill the night before, when it becomes very noisy and dies on the side of the road. After skilled examination a broken crankshaft is revealed on this brand new tractor.
There then comes a lengthy recovery procedure to get the vehicle back on the road.
One thing's for sure: this has been the one and only potato harvest I will risk my life and licence on. Give me back my Scania.